杨永, 王新华, 陈迎春, 位凯玲. 交流干扰下X100管线钢及其热影响区在库尔勒土壤模拟液中的腐蚀行为[J]. 工程科学学报, 2020, 42(7): 894-901. DOI: 10.13374/j.issn2095-9389.2019.07.21.002
引用本文: 杨永, 王新华, 陈迎春, 位凯玲. 交流干扰下X100管线钢及其热影响区在库尔勒土壤模拟液中的腐蚀行为[J]. 工程科学学报, 2020, 42(7): 894-901. DOI: 10.13374/j.issn2095-9389.2019.07.21.002
YANG Yong, WANG Xin-hua, CHEN Ying-chun, WEI Kai-ling. Corrosion behavior of X100 pipeline steel and its heat-affected zones in simulated Korla soil solution under alternating current interference[J]. Chinese Journal of Engineering, 2020, 42(7): 894-901. DOI: 10.13374/j.issn2095-9389.2019.07.21.002
Citation: YANG Yong, WANG Xin-hua, CHEN Ying-chun, WEI Kai-ling. Corrosion behavior of X100 pipeline steel and its heat-affected zones in simulated Korla soil solution under alternating current interference[J]. Chinese Journal of Engineering, 2020, 42(7): 894-901. DOI: 10.13374/j.issn2095-9389.2019.07.21.002

交流干扰下X100管线钢及其热影响区在库尔勒土壤模拟液中的腐蚀行为

Corrosion behavior of X100 pipeline steel and its heat-affected zones in simulated Korla soil solution under alternating current interference

  • 摘要: 通过Gleeble热模拟实验机模拟了X100管线钢的粗晶热影响区(CGHAZ)及再热临界粗晶热影响区(ICCGHAZ)微观组织。采用电化学测试、浸泡实验及表面分析技术研究了交流干扰下X100管线钢母材、CGHAZ及ICCGHAZ在库尔勒土壤溶液中的腐蚀行为。结果表明:交流干扰下X100管线钢母材、CGHAZ及ICCGHAZ都表现为活性溶解,平均腐蚀速率随交流电流密度的增大而增加。交流干扰造成的极化电位振荡幅值及微观组织对X100管线钢母材、CGHAZ及ICCGHAZ的平均腐蚀速率和腐蚀形貌有着重要影响。在5 mA·cm‒2交流电流密度干扰下,母材的腐蚀电位最负、平均腐蚀速率最大,ICCGHAZ的腐蚀电位最正、平均腐蚀速率最小,CGHAZ的腐蚀电位及平均腐蚀速率都居中;在20 mA·cm‒2及50 mA·cm‒2交流电流密度干扰下,ICCGHAZ腐蚀电位最负、平均腐蚀速率最大,母材的腐蚀电位最正、平均腐蚀速率最小,CGHAZ的腐蚀电位及平均腐蚀速率都仍居中。在20 mA·cm‒2交流电流密度交流干扰下,X100管线钢发生局部腐蚀,CGHAZ、ICCGHAZ发生明显的晶界腐蚀,GCHAZ晶界腐蚀形貌呈缝隙状、ICCGHAZ晶界腐蚀形貌为连续孔洞。

     

    Abstract: In recent years, many accidents caused by alternating current (AC) corrosion have been reported. AC corrosion has become a serious potential damage to buried steel pipelines. The X100 pipeline steel is a very promising material for long-distance gas pipelines, and Korla soil is a typical saline-alkali soil of West China. The coarse-grained heat-affected zone (CGHAZ) and the intercritically reheated coarse-grained heat-affected zone (ICCGHAZ) were simulated by a Gleeble thermomechanical processing machine through different thermal cycle times, peak temperatures, and cooling rates. Electrochemical corrosion measurements, immersion experiments and surface analysis techniques were used to characterize the corrosion behavior of the base metal, CGHAZ, and ICCGHAZ of the X100 pipeline steel in simulated Korla soil solution under AC interference. The X100 pipeline steel base metal, CGHAZ, and ICCGHAZ exhibited active dissolution in the simulated Korla soil solution under AC interference, and the average corrosion rate increased with the increase in AC density. The amplitude of the polarization potential oscillation caused by AC interference and the microstructure had an important influence on the corrosion rate and corrosion morphology of the X100 pipeline steel base metal, CGHAZ and ICCGHAZ. Under the interference of 5 mA·cm‒2 AC density, the X100 pipeline steel base material shows the most negative corrosion potential and the largest average corrosion rate, while the ICCGHAZ shows the most positive corrosion potential and the smallest average corrosion rate. Under the interferences of 20 and 50 mA·cm‒2 AC densities, the ICCGHAZ of X100 pipeline steel shows the most negative corrosion potential and the largest average corrosion rate, while the base metal shows the most positive corrosion potential and the smallest average corrosion rate. Under the interference of 20 mA·cm‒2 AC density, the X100 pipeline steel is locally corroded. CGHAZ and ICCGHAZ have obvious grain boundary corrosion, whereby GCHAZ grain boundary corrosion morphology is slit-shaped, and ICCGHAZ grain boundary corrosion morphology is continuous pores.

     

/

返回文章
返回