刘伟建, 史成斌, 徐昊驰, 郑顶立, 吕士刚, 李晶, 郭宝善. 气氛保护电渣重熔过程中氧化物–CaS复合夹杂物的演变[J]. 工程科学学报, 2020, 42(S): 109-118. DOI: 10.13374/j.issn2095-9389.2020.03.12.s08
引用本文: 刘伟建, 史成斌, 徐昊驰, 郑顶立, 吕士刚, 李晶, 郭宝善. 气氛保护电渣重熔过程中氧化物–CaS复合夹杂物的演变[J]. 工程科学学报, 2020, 42(S): 109-118. DOI: 10.13374/j.issn2095-9389.2020.03.12.s08
LIU Wei-jian, SHI Cheng-bin, XU Hao-chi, ZHENG Ding-li, LÜ Shi-gang, LI Jing, GUO Bao-shan. Evolution of oxide–CaS complex inclusions during protective atmosphere electroslag remelting[J]. Chinese Journal of Engineering, 2020, 42(S): 109-118. DOI: 10.13374/j.issn2095-9389.2020.03.12.s08
Citation: LIU Wei-jian, SHI Cheng-bin, XU Hao-chi, ZHENG Ding-li, LÜ Shi-gang, LI Jing, GUO Bao-shan. Evolution of oxide–CaS complex inclusions during protective atmosphere electroslag remelting[J]. Chinese Journal of Engineering, 2020, 42(S): 109-118. DOI: 10.13374/j.issn2095-9389.2020.03.12.s08

气氛保护电渣重熔过程中氧化物–CaS复合夹杂物的演变

Evolution of oxide–CaS complex inclusions during protective atmosphere electroslag remelting

  • 摘要: 利用扫描电镜分析了自耗电极和电渣重熔钢中夹杂物的特征,结合热力学计算,分析了氧硫复合夹杂物在电渣重熔过程中的转变机理。结果表明,电渣重熔采用气氛保护结合脱氧操作可以将自耗电极全氧质量分数由0.0017%降低至0.0008%。电渣重熔之后钢中小于3 μm夹杂物的比例显著增加。自耗电极中的夹杂物为CaS与含质量分数3%和11%左右MgO的CaO–Al2O3–SiO2–MgO结合的两类复合夹杂物。电渣过程未被去除的氧化物夹杂中的SiO2被钢液中酸溶铝还原,保留至电渣锭中。电渣锭中含约1%MgO和2%SiO2且成分均匀的CaO–Al2O3–SiO2–MgO是在电渣过程中新生的夹杂物。自耗电极中的CaS通过分解为钢液中溶解Ca和S,以及通过与液态氧化物夹杂中Al2O3反应的途径在电渣过程被去除。电渣锭中低熔点氧化物夹杂周围环状CaS是钢液凝固过程中溶解S、酸溶铝Al与氧化物夹杂中CaO的反应产物,高熔点氧化物夹杂周围环状CaS是钢液凝固过程中Ca和S偏析后反应新生的夹杂物。复合夹杂物中补丁状CaS是在电渣重熔钢液冷却过程中由复合夹杂物熔体中析出的。

     

    Abstract: The inclusions in the consumable steel electrode and electroslag remelted steel were characterized using a scanning electron microscope (SEM) equipped with an energy dispersive X-ray spectrometer (EDS). The evolution mechanism of oxide–sulfide complex inclusions during electroslag remelting (ESR) was elucidated based on inclusion experimental identification and thermodynamic calculation. The results show that the combination of protective atmosphere and deoxidation operation during ESR lowers the total oxygen content from 0.0017% in the electrode to 0.0008% in the ingot. The number proportion of the inclusions smaller than 3 μm in the steel greatly increases after ESR. The inclusions in the steel electrode are two oxide–sulfide complex types of CaS+CaO–Al2O3–SiO2–MgO containing about 3% MgO and CaS+CaO–Al2O3–SiO2–MgO containing about 11% MgO. SiO2 in the original oxide inclusions that had not been removed in ESRR process was reduced by soluble aluminum in liquid steel, and the products remain in the ESR process until in remelted ingot. The CaO–Al2O3–SiO2–MgO inclusions with uniform elements distribution, which contain about 1%MgO and about 2%SiO2, in the ingot are newly formed oxide inclusions in the ESR. CaS inclusions in the steel electrode were removed during the ESR through dissociating into soluble calcium and sulfur in liquid steel, and in the way of reacting with Al2O3 in liquid oxide inclusions. The shell-type CaS around low-melting-temperature oxide inclusion generated as a result of the reaction between CaO in the oxide inclusion and dissolved aluminum and sulfur in liquid steel during solidification of liquid steel in the ESR process. The shell-type CaS around high-melting-temperature oxide inclusion is the reaction products of enriched soluble Ca and S during solidification of liquid steel. Patch-type CaS in the oxide–sulfide complex inclusion precipitated from the complex inclusion melt during the cooling of liquid steel in the ESR process.

     

/

返回文章
返回