刘征建, 王耀祖, 张建良, 张亚鹏, 左海滨. 支撑板对烧结过程的影响[J]. 工程科学学报, 2016, 38(2): 200-206. DOI: 10.13374/j.issn2095-9389.2016.02.007
引用本文: 刘征建, 王耀祖, 张建良, 张亚鹏, 左海滨. 支撑板对烧结过程的影响[J]. 工程科学学报, 2016, 38(2): 200-206. DOI: 10.13374/j.issn2095-9389.2016.02.007
LIU Zheng-jian, WANG Yao-zu, ZHANG Jian-liang, ZHANG Ya-peng, ZUO Hai-bin. Effects of stand-support on the sintering process[J]. Chinese Journal of Engineering, 2016, 38(2): 200-206. DOI: 10.13374/j.issn2095-9389.2016.02.007
Citation: LIU Zheng-jian, WANG Yao-zu, ZHANG Jian-liang, ZHANG Ya-peng, ZUO Hai-bin. Effects of stand-support on the sintering process[J]. Chinese Journal of Engineering, 2016, 38(2): 200-206. DOI: 10.13374/j.issn2095-9389.2016.02.007

支撑板对烧结过程的影响

Effects of stand-support on the sintering process

  • 摘要: 烧结料层上部荷重是造成烧结过程中燃烧熔融带透气性差的重要因素,而烧结料层透气性是制约我国厚料层烧结技术进一步发展的限制性环节.从减轻烧结料层燃烧熔融带荷重以及改善烧结过程料层透气性的角度出发,通过在烧结料层中安装支架研究不同荷重条件下对铁矿粉烧结行为的影响.烧结杯实验研究表明:安装支撑板后,烧结料层透气性明显改善,烧结矿转鼓强度大于65%;垂直烧结速度显著提高,最高可达28.4 mm·min-1;成品率波动幅度不大,利用系数从1.89 t·m-2·h-1增加到2.31 t·m-2·h-1;燃耗有所降低,最大降幅达1.32%.理论分析和实验表明,支撑板对减轻烧结熔融带上部荷重,提高料层透气性,以及改善燃耗和烧结矿质量具有重要意义.

     

    Abstract: The load from the upper sinter bed is one of the important factors which deteriorate the permeability of the combustion zone in the sintering process, which restricts the further development of thick bed sintering. To reduce the load of the sinter bed and improve the permeability of the combustion zone, the influences of different loads which were coordinated by the height of support stands on the combustion zone and sinter bed were researched. Sintering pot test results indicated that the permeability of the combustion zone and sinter bed was obviously improved after the support stand being installed in the sinter bed and the tumble index (TI) of sinter ores were more than 65%. The velocity of sintering dramatically increased and achieved the maximum value of 28.4 mm. rain-i The yield of sinter ores did not significantly change compared to ordinary sintering process. The sinter productivity increased from 1.89 t·m-2·h-1 to 2. 31 t·m-2·h-1. The fuel consumption of the sintering process decreased by 1.32%. Theoretical analysis and experiments showed that load reduction sintering process had a positive impact on the permeability of the sinter bed, resulting in the decrease of fuel consumption and the improvement of sinter quality.

     

/

返回文章
返回