吴华杰, 蒋芳杰, 李巧琦, 张漓, 张永超. VD过程钢渣混卷行为的水模型[J]. 工程科学学报, 2018, 40(S1): 147-153. DOI: 10.13374/j.issn2095-9389.2018.s1.021
引用本文: 吴华杰, 蒋芳杰, 李巧琦, 张漓, 张永超. VD过程钢渣混卷行为的水模型[J]. 工程科学学报, 2018, 40(S1): 147-153. DOI: 10.13374/j.issn2095-9389.2018.s1.021
WU Hua-jie, JIANG Fang-jie, LI Qiao-qi, ZHANG Li, ZHANG Yong-chao. Physical modeling on the mixing behavior of molten steel and slag in VD process[J]. Chinese Journal of Engineering, 2018, 40(S1): 147-153. DOI: 10.13374/j.issn2095-9389.2018.s1.021
Citation: WU Hua-jie, JIANG Fang-jie, LI Qiao-qi, ZHANG Li, ZHANG Yong-chao. Physical modeling on the mixing behavior of molten steel and slag in VD process[J]. Chinese Journal of Engineering, 2018, 40(S1): 147-153. DOI: 10.13374/j.issn2095-9389.2018.s1.021

VD过程钢渣混卷行为的水模型

Physical modeling on the mixing behavior of molten steel and slag in VD process

  • 摘要: 通过水模型研究了VD精炼过程的钢渣混卷行为, 定义了钢渣临界半混和临界全混状态, 并对不同底吹气量、真空度、底吹位置下的混合状态进行了研究;分析了临界搅拌功率和流场稳定性对混卷行为的影响.结果表明:在实验条件下, 临界半混和临界全混气量随着真空度的增大而减小;2/3R双孔底吹位置的临界气量大于2/3R+中心孔底吹位置的;并基于导出的真空度与底吹气量拟合公式, 外推出真空度为67 Pa时实际生产过程中的临界气量;VD过程钢包流场特性主要受底吹位置影响, 并进一步影响混卷行为, 在稳定性流场中当钢渣混合达到同一状态时, 搅拌功率几乎是定值.

     

    Abstract: The mixing behavior of molten steel and slag has an important impact on refining effect in vacuum degassing (VD) process.In the VD refining process, the vacuum condition makes the bottom argon gas agitate the molten steel vigorously, and increase the exposed molten steel area, which not only aggravates the degree of steel slag mixing in the ladle, but also promotes the degassing reaction in molten steel.Moreover, it has an important influence on the desulfurization effect of molten steel.In the actual melting process, the exposed situation of the molten steel can be observed over the slag, but the steel and slag mixing situation in the ladle cannot be observed.Therefore, it has a great practical significance to study the slag mixing behavior in VD refining process under the different process conditions.In the water model experiment, the critical condition of half-mixing and complete-mixing was first defined.And then the impacts of the total blowing flow rate, vacuum degree, and the bottom blowing positions on half-mixing and complete-mixing were discussed.Besides, the effects of critical stirring energy density and stability of flow field on mixing behavior were also analyzed.The results indicate that half-mixing and complete-mixing critical gas flow rate decreases with the increase of vacuum degree in the laboratory condition.And the critical gas flow rate in 2/3R+2/3R is greater than that in 2/3R+center hole.In addition, the fitting formulas of vacuum degree and critical gas flow rate were given.Based on fitting formulas, critical gas flow rate in actual VD process was obtained when vacuum degree was 67 Pa.According to the results, the critical stirring energy density is nearly a constant when the steel-slag mixing reaches the same condition in steady flow field, which indicates that flow character can further influence mixing effect and it is affected by the bottom blowing positions.

     

/

返回文章
返回