王雷鸣, 李辉, 尹升华, 潘晨阳, 廖文胜. 基于形态学开运算的浸矿体系孔隙结构及其演化特征[J]. 工程科学学报, 2024, 46(2): 199-208. DOI: 10.13374/j.issn2095-9389.2022.12.01.001
引用本文: 王雷鸣, 李辉, 尹升华, 潘晨阳, 廖文胜. 基于形态学开运算的浸矿体系孔隙结构及其演化特征[J]. 工程科学学报, 2024, 46(2): 199-208. DOI: 10.13374/j.issn2095-9389.2022.12.01.001
WANG Leiming, LI Hui, YIN Shenghua, PAN Chenyang, LIAO Wensheng. Pore structure and its evolution characterization in leaching systems via morphological open operation[J]. Chinese Journal of Engineering, 2024, 46(2): 199-208. DOI: 10.13374/j.issn2095-9389.2022.12.01.001
Citation: WANG Leiming, LI Hui, YIN Shenghua, PAN Chenyang, LIAO Wensheng. Pore structure and its evolution characterization in leaching systems via morphological open operation[J]. Chinese Journal of Engineering, 2024, 46(2): 199-208. DOI: 10.13374/j.issn2095-9389.2022.12.01.001

基于形态学开运算的浸矿体系孔隙结构及其演化特征

Pore structure and its evolution characterization in leaching systems via morphological open operation

  • 摘要: 立足堆浸体系的偏析分层复杂结构,结合X-ray CT无损探测、形态学开运算处理、MATLAB和OsiriX可视化软件等手段,引入颗粒间孔隙的当量孔隙尺寸、面积、数量等关键表征参量,如从二维量化和三维可视化层面揭示浸矿体系中颗粒间孔隙结构特征及其演化规律. 研究发现,细颗粒夹层呈“包裹体”状且均位于粗矿石颗粒的内部,分析认为其是造成堆浸体系颗粒偏析和分层的重要致因;浸矿作用下微细颗粒迁移导致矿堆内部发生沉积压实作用,由197 mm降至180 mm以下;浸矿21 d后,矿堆上部孔隙呈增大趋势,下部孔隙率呈减小趋势,此外,纵向当量孔隙的直径由2.81 mm减小至2.18 mm,其变化趋势和程度要显著大于横向颗粒间孔隙的当量直径;对比浸矿0 d和21 d的柱浸体系三维颗粒间孔隙结构,证实了细颗粒夹层所处区域的粘结聚集以及细颗粒夹层周边区域形成溶液绕流、溶液优势流动路径.

     

    Abstract: Heap leaching has been widely used in mining low-grade sulfide copper minerals because of its outstanding advantages of low cost, fast infrastructure, and effective recovery. However, the segregation and stratification of crushed ore feeds during the dumping and stacking process of heap leaching are significant and prone to occur, leading to preferential flow paths and low heap leaching efficiency. Based on the complex segregation and layered structure of the heap leaching system, combined with X-ray CT nondestructive detection, morphological open operation processing, MATLAB and OsiriX visualization software, and other means, the key characterization parameters, such as the equivalent pore size, area, and number of pores between particles, are introduced. This study explores the intergranular pore structure characteristics and evolution regulation of the leaching system from the perspective of two-dimensional quantification and three-dimensional visualization. This study found that the fine interlayers are in the shape of “inclusions” and are inside the coarse ore particles. The analysis demonstrates that it is an important cause of particle segregation and stratification in the heap leaching system. The migration of fine particles under the action of ore leaching leads to sedimentary compaction, which decreased from 197 mm to below 180 mm. After 21 days of ore leaching, the pores in the upper and lower parts of the ore heap showed increasing and decreasing trends, respectively. In addition, the diameter of the longitudinal equivalent pores decreased from 2.81 to 2.18 mm; the change trend and extent were considerably greater than the equivalent diameter of the transverse intergranular pores. When comparing the three-dimensional intergranular pore structures of the column leaching system for 0 and 21 days of ore leaching, it is evident that the fine particle interlayer is located in the bonding and aggregation region. The peripheral area of the fine particle interlayer also forms the circumvention and dominant flow path of the solution. This suggests the coexistence of hydraulic erosion and reactive dissolution in the heap leaching system. The combined effect of these processes leads to bonding and aggregation in the area where the fine particle interlayer is located, forming solution and dominant flow paths in the area surrounding the fine particle interlayer. These preferential flow paths may result in the solution not actually participating in the leaching reaction and leaving the heap leaching system, which is undesirable and should be avoided in real heap leaching systems.

     

/

返回文章
返回